Open Access Open Access  Restricted Access Subscription or Fee Access

Review article: Improvement of Permeate flux by Laboratory Scale Techniques in Membrane Separation Processes

Jigesh Pankaj Mehta

Abstract


Membrane separation processes are found to be most effective and innovative technique in terms of separating the different attacking materials which are involved in mitigation of membrane filtration technique at some end. Various laboratory scale techniques are involved in the present era to meet the demands of current industrial requirements in terms of cost and quality. This article is an short review on three different flux enhancement techniques applied on laboratory scale found useful in delivering the proper solution to various feed ingredients which are to some extent creates difficulty to the allied industries.


Keywords


Mitigation, Flux, Laboratory scale, allied industries

Full Text:

PDF

References


Kaushik Nath, Membrane Separation Process, PHI learning pvt ltd, New Delhi, 2011.

G. Ducom, H. Matamoros, C. Cabassud. Air sparging for flux enhancement in nanofiltration membranes: application to O/W stabilised and non-stabilised emulsions. Journal of Membrane Science 2002; 204(1-2); 221–236.

N. Javadi, F.Z. Ashtiani, A. Fouladitajar, et al. Experimental studies and statistical analysis of membrane fouling behavior and performance in microfiltration of microalgae by a gas sparging assisted process. Bioresource Technology 2014; 162; 350–357.

A. Laorko, Z. Li, S. Tongchitpakdee, et al. Effect of gas sparging on flux enhancement and phytochemical properties of clarified pineapple juice by microfiltration. Separation and Purification Technology 2011; 80(3); 445–451.

C. Cabassud, S. Laborie, J.M. Laine. How slug flow can improve ultrafiltration flux in organic hollow fibres. Journal of Membrane Science 1997; 128(1); 93-101.

X. Shi, G. Tal, N.P. Hankins, et al. Fouling and cleaning of ultrafiltration membranes: A review. Journal of Water Process Engineering 2014; 1; 121–138.

M. Hemmati , F. Rekabdar , A. Gheshlaghi , et al. Effects of air sparging, cross flow velocity and pressure on permeation flux enhancement in industrial oily wastewater treatment using microfiltration. Desalination and Water Treatment 2012; 39(1-3); 33–40.

N. Yin, Z. Zhong, W. Xing. Ceramic membrane fouling and cleaning in ultrafiltration of desulfurization wastewater. Desalination 2013; 319; 92–98.

Z. Wang, F. Meng, X. He, et al. Optimisation and performance of NaClO-assisted maintenance cleaning for fouling control in membrane bioreactors. Water Research 2014; 53; 1-11.

K.R. Goode, K. Asteriadou, P.T. Robbins, et al. Fouling and Cleaning Studies in the Food and Beverage Industry Classified by Cleaning Type. Comprehensive Reviews in Food Science and Food Safety 2013; 12(2); 121-143.

B.P. Espinasse, S. Chae, C. Marconnet, et al. Comparison of chemical cleaning reagents and characterization of foulants of nanofiltration membranes used in surface water treatment. Desalination 2012; 296; 1–6.

A.L. Ahmad, N.H. Mat Yasin, C.J.C. Derek, et al. Chemical cleaning of a cross-flow microfiltration membrane fouled by microalgal biomass. Journal of the Taiwan Institute of Chemical Engineers 2014; 45(1); 233–241.

V. Naddeo, V. Belgiorno, L. Borea, et al. Control of fouling formation in membrane ultrafiltration by ultrasound irradiation. Environmental Technology 2015; 36(10); 1299–1307.

X. Li, J. Yu, A.G. Agwu Nnanna. Fouling mitigation for hollow-fiber UF membrane by sonication. Desalination 2011; 281; 23–29.

T.M. Patel, K. Nath. Alleviation of flux decline in cross flow nanofiltration of two-component dye and salt mixture by low frequency ultrasonic irradiation. Desalination 2013; 317; 132–141.

Y. Tao, D. Sun. Enhancement of Food Processes by Ultrasound: A Review. Critical Reviews in Food Science and Nutrition 2015; 55(4); 570-594.

M.H. Shahraki, A. Maskooki, A.Faezian. Effect of various sonication modes on permeation flux in cross flow ultrafiltration membrane. Journal of Environmental Chemical Engineering 2014; 2(4); 2289–2294.

A. Mirzaie, T. Mohammadi. Effect of ultrasonic waves on flux enhancement in microfiltration of milk. Journal of Food Engineering 2012; 108(1); 77–86.




DOI: https://doi.org/10.37591/jomcct.v10i1.1706

Refbacks

  • There are currently no refbacks.